赤泥在沼液除磷中的应用

李晓光; 赵颖; 康得军; 杨天学; 龚斌; 张颖; 刘娇妹; 卓锦德; 曾宇平

doi:10.3969/j.issn.1674-991X.2018.04.057

赤泥在沼液除磷中的应用

doi: 10.3969/j.issn.1674-991X.2018.04.057

^1. 北京低碳清洁能源研究所,北京 102211
^2. 中国环境科学研究院,北京 100012
^3. 福州大学,福建福州 350108
^4. 中国科学院上海硅酸盐研究所,上海 200050

详细信息

作者简介:
李晓光(1982—),女,工程师,博士,主要从事固体废物高值化利用和环境水体净化材料研发与应用研究

中图分类号: X703
计量
- 文章访问数: 555
- HTML全文浏览量: 71
- PDF下载量: 443
- 被引次数: 0
出版历程
- 收稿日期: 2018-02-05
- 刊出日期: 2018-07-20

Study on phosphorus removal from biogas slurry by red mud

^1. National Institute of Clean-and-Low-Carbon Energy(NICE), Beijing 102211, China
^2. Chinese Research Academy of Environmental Sciences, Beijing 100012, China
^3. Fuzhou University, Fuzhou 350108, China
^4. Shanghai Institute of Ceramics, Chinese Academy of Sciences, Shanghai 200050, China;

摘要

摘要: 采用工业废物赤泥去除沼液中磷酸盐,利用XRF、XRD、PSD和SEM等手段对赤泥基本物理化学性质进行了综合表征,研究了沼液初始pH(pH_i)、赤泥投加量、反应时间和初始磷浓度等因素对沼液中磷酸盐去除率和沼液最终pH(pH_f)的影响。结果表明:沼液中磷酸盐去除率随着pH_i的增加呈先降低后增加趋势;磷酸盐去除率最大值和最小值分别出现在pH_i为2.1和6.9处,分别为89.6%和47.2%;赤泥投加量越大、反应时间越长,磷酸盐去除率越高,pH_f越大;而初始磷浓度越低,磷酸盐去除率越高,pH_f越大。采用3 ⁴水平正交试验设计考察了各因素间的交互作用及对赤泥除磷的影响,得到赤泥除磷的最佳条件:pH_i为10.0,赤泥投加量为5.0 g/L,初始磷浓度为1.7 mg/L,反应时间为40 min。
- 沼液 /
- 赤泥 /
- 正交试验 /
- 磷酸盐去除
Abstract: The red mud(RM), an industrial waste of alumina production, was applied to remove phosphorus from biogas slurry. The XRF, XRD, PSD and SEM tests were employed to assess the physicochemical properties of RM. Some important parameters that affect the phosphorus removal efficiency and final pH of solution(pH_f), such as initial pH(pH_i), RM dosage, reaction time and phosphate concentration of biogas slurry were explored. The results indicated that the phosphate removal efficiency decreased first, and then increased with the increase of pH. And the highest and the lowest phosphate removal efficiency were 89.6% and 47.2%, under the conditions of pH_i 2.1 and 6.9, respectively. The RM dosage and contact time had a positive effect, whereas initial phosphate concentration had a negative effect on phosphate removal and pH_f. The effects of individual variables on phosphate removal were determined by using a 3 ⁴ orthogonal experiment design. The results showed that the optimal reaction conditions were as follows: pH_i 10.0, RM dosage 5.0 g/L, initial phosphate concentration 1.7 mg/L, and contact time 40 min.
- biogas slurry /
- red mud /
- orthogonal experiment /
- phosphorus removal

HTML全文

参考文献(29)

[1]	HAN C, WANG Z, YANG H , et al. Removal kinetics of phosphorus from synthetic wastewater using basic oxygen furnace slag[J]. Journal of Environmental Sciences, 2015,30:21-29. doi: 10.1016/j.jes.2014.11.003 pmid: 25872706
[2]	QIU L, ZHENG P, ZHANG M , et al. Phosphorus removal using ferric-calcium complex as precipitant:parameters optimization and phosphorus-recycling potential[J]. Chemical Engineering Journal, 2015,268:230-235. doi: 10.1016/j.cej.2014.12.107
[3]	LÜRLING M, WAAJEN G, van OOSTERHOUT F . Humic substances interfere with phosphate removal by lanthanum modified clay in controlling eutrophication[J]. Water Research, 2014,54:78-88. doi: 10.1016/j.watres.2014.01.059 pmid: 24565799
[4]	周艳伟, 易莹, 谢乔光 , 等. 沼液中磷的去除与回收技术研究进展[J]. 安徽农业科学, 2014,42(30):10701-10704. doi: 10.3969/j.issn.0517-6611.2014.30.095 ZHOU Y W, YI Y, XIE Q G , et al. Research progress of phosphorus pemoval and pecovery from the digested effluent[J]. Journal of Anhui Agricultural Sciences, 2014,42(30):10701-10704. doi: 10.3969/j.issn.0517-6611.2014.30.095
[5]	LIU J, SU Y, LI Q , et al. Preparation of wheat straw based superabsorbent resins and their applications as adsorbents for ammonium and phosphate removal[J]. Bioresource Technology, 2013,143:32-39. doi: 10.1016/j.biortech.2013.05.100 pmid: 23786713
[6]	YANG S, ZHAO Y, CHEN R , et al. A novel tablet porous material developed as adsorbent for phosphate removal and recycling[J]. Journal of Colloid and Interface Science, 2013,396:197-204. doi: 10.1016/j.jcis.2012.12.077 pmid: 23484953
[7]	PITAKTEERATHAM N, HAFUKA A, SATOH H , et al. High efficiency removal of phosphate from water by zirconium sulfate-surfactant micelle mesostructure immobilized on polymer matrix[J]. Water Research, 2013,47(11):3583-3590. doi: 10.1016/j.watres.2013.04.006 pmid: 23726694
[8]	BARAT R, MONTOYA T, SECO A , et al. Modelling biological and chemically induced precipitation of calcium phosphate in enhanced biological phosphorus removal systems[J]. Water Research, 2011,45(12):3744-3752. doi: 10.1016/j.watres.2011.04.028 pmid: 21565382
[9]	OEHMEN A, CARVALHO G, LOPEZ-VAZQUEZ C M ,et al. Incorporating microbial ecology into the metabolic modelling of polyphosphate accumulating organisms and glycogen accumulating organisms[J]. Water Research, 2010,44(17):4992-5004. doi: 10.1016/j.watres.2010.06.071 pmid: 20650504
[10]	CHOI J W, LEE S Y, LEE S H , et al. Adsorption of phosphate by amino-functionalized and co-condensed SBA-15[J]. Water,Air & Soil Pollution, 2012,223(5):2551-2562. doi: 10.1007/s11270-011-1047-7
[11]	LIU J, SU Y, LI Q , et al. Preparation of wheat straw based superabsorbent resins and their applications as adsorbents for ammonium and phosphate removal[J]. Bioresource Technology, 2013,143:32-39. doi: 10.1016/j.biortech.2013.05.100 pmid: 23786713
[12]	SONG X, PAN Y, WU Q , et al. Phosphate removal from aqueous solutions by adsorption using ferric sludge[J]. Desalination, 2011,280(1):384-390. doi: 10.1016/j.desal.2011.07.028
[13]	CHEN J, KONG H, WU D , et al. Phosphate immobilization from aqueous solution by fly ashes in relation to their composition[J]. Journal of Hazardous Materials, 2007,139(2):293-300. doi: 10.1016/j.jhazmat.2006.06.034 pmid: 16860931
[14]	ZHAO Y, ZHANG L, NI F , et al. Evaluation of a novel composite inorganic coagulant prepared by red mud for phosphate removal[J]. Desalination, 2011,273(2):414-420. doi: 10.1016/j.desal.2011.01.065
[15]	ZHAO Y, WANG J, LUAN Z , et al. Removal of phosphate from aqueous solution by red mud using a factorial design[J]. Journal of Hazardous Materials, 2009,165(1):1193-1199. doi: 10.1016/j.jhazmat.2008.10.114 pmid: 19091463
[16]	NI F, HE J, WANG Y , et al. Preparation and characterization of a cost-effective red mud/polyaluminum chloride composite coagulant for enhanced phosphate removal from aqueous solutions[J]. Journal of Water Process Engineering, 2015,6:158-165. doi: 10.1016/j.jwpe.2015.04.003
[17]	ZHAO Y, WANG J, LIU C , et al. Characterization and risk assessment of red mud derived from the sintering alumina process[J]. Fresenius Environmental Bulletin, 2009,18(6):989-993.
[18]	BURKE I T, MAYES W M, PEACOCK C L , et al. Speciation of arsenic,chromium,and vanadium in red mud samples from the Ajka spill site,Hungary[J]. Environmental Science & Technology, 2012,46(6):3085-3092. doi: 10.1021/es3003475 pmid: 22324637
[19]	ZHANG S, LIU C, LUAN Z , et al. Arsenate removal from aqueous solutions using modified red mud[J]. Journal of Hazardous Materials, 2008,152(2):486-492. doi: 10.1016/j.jhazmat.2007.07.031 pmid: 17826896
[20]	SUSHIL S, BATRA V S . Catalytic applications of red mud,an aluminium industry waste:a review[J]. Applied Catalysis B:Environmental, 2008,81(1):64-77. doi: 10.1016/j.apcatb.2008.06.001
[21]	WANG S, BOYJOO Y, CHOUEIB A , et al. Removal of dyes from aqueous solution using fly ash and red mud[J]. Water Research, 2005,39(1):129-138. doi: 10.1016/j.watres.2004.09.011 pmid: 15607172
[22]	ARNOLD E . Standard methods for the examination of water and wastewater[M]. 16th ed.New York:American Public Health Association, 1985: 445-446.
[23]	IMAMOGLU M, TEKIR O . Removal of copper(Ⅱ)and lead(Ⅱ)ions from aqueous solutions by adsorption on activated carbon from a new precursor hazelnut husks[J]. Desalination, 2008,228(1/2/3):108-113. doi: 10.1016/j.desal.2007.08.011
[24]	王东升, 汤鸿霄 . 聚铁硅型复合无机高分子絮凝剂的形态分布特征[J]. 环境科学, 2001,22(1):94-97. doi: 10.3321/j.issn:0250-3301.2001.01.023 WANG D S, TANG H X . Characterization of speciation distribution of IPF-PFSi[J]. Environmental Science, 2001,22(1):94-97. doi: 10.3321/j.issn:0250-3301.2001.01.023
[25]	邢赜, 陈玉成, 熊佰炼 , 等. 不同沸石材料对沼液中磷素静态吸附去除[J]. 环境工程学报, 2013,7(2):494-500. XING Z, CHEN Y C, XIONG B L , et al. Static adsorption characteristics and removal efficiency of phosphate in biogas slurry by different zeolite substrates[J]. Chinese Journal of Environmental Engineering, 2013,7(2):494-500.
[26]	HAGHSERESHT F, WANG S, DO D d . A novel lanthanum-modified bentonite,phoslock,for phosphate removal from wastewaters[J]. Applied Clay Science, 2009,46(4):369-375. doi: 10.1016/j.clay.2009.09.009
[27]	CAN M Y, YILDIZ E . Phosphate removal from water by fly ash:factorial experimental design[J]. Journal of Hazardous Materials, 2006,135(1):165-170. doi: 10.1016/j.jhazmat.2005.11.036 pmid: 16359787
[28]	LIU C J, LI Y Z, LUAN Z K , et al. Adsorption removal of phosphate from aqueous solution by active RM[J]. Journal of Environmental Sciences, 2007,19(10):1166-1170. doi: 10.1016/S1001-0742(07)60190-9 pmid: 18062412
[29]	盛骤, 谢式千, 潘城毅 . 概率论与数理统计[M]. 北京: 高等教育出版社, 2008.