生物沸石人工湿地强化硝化处理污水处理厂二级出水研究

胡杰军; 董婧; 沈志强; 周岳溪; 陈学民; 伏小勇

doi:10.3969/j.issn.1674-991X.2018.03.036

生物沸石人工湿地强化硝化处理污水处理厂二级出水研究

doi: 10.3969/j.issn.1674-991X.2018.03.036

胡杰军^1,2,
董婧³,
沈志强^2,4,
周岳溪^2,4,*, ,,
陈学民¹,
伏小勇¹

^1. 兰州交通大学环境与市政工程学院,甘肃兰州 730070
^2. 中国环境科学研究院水污染控制技术研究中心,北京 100012
^3. 北京市环境保护科学研究院,北京 100037
^4. 环境基准与风险评估国家重点实验室,中国环境科学研究院,北京 100012

详细信息

作者简介:
胡杰军(1990—),女,硕士,主要从事水污染控制技术研究, 1024513474@qq.com

通讯作者:
周岳溪 E-mail: zhouyuexi@263.net

中图分类号: X703
计量
- 文章访问数: 629
- HTML全文浏览量: 108
- PDF下载量: 261
- 被引次数: 0
出版历程
- 收稿日期: 2017-12-14
- 刊出日期: 2018-05-20

Nitrification performance for secondary effluent from MWTP using bio-zeolite constructed wetland

^1. School of Environmental and Municipal Engineering, Lanzhou Jiaotong University, Lanzhou 730070, China
^2. Research Center of Water Pollution Control Technology, Chinese Research Academy of Environmental Sciences, Beijing 100012, China
^3. Beijing Municipal Research Institute of Environmental Protection, Beijing 100037, China
^4. State Key Laboratory of Environmental Criteria and Risk Assessment, Chinese Research Academy of Environmental Sciences, Beijing 100012

More Information

Corresponding author: Yuexi ZHOU E-mail: zhouyuexi@263.net

摘要

摘要: 以生物沸石人工湿地(CW)中试装置处理实际城镇污水处理厂二级出水,通过273 d的运行,探讨了生物沸石人工湿地强化硝化处理二级出水的性能及温度对其硝化率的影响。结果表明:生物沸石人工湿地能够快速高效地去除二级出水中的氨氮,正常运行阶段氨氮平均去除率达90.5%,出水氨氮平均浓度低于0.5 mg/L。系统重启恢复快、周期短,12 d后氨氮平均去除率达到70%以上。低温阶段(低于13 ℃),生物沸石人工湿地对氨氮的平均去除率依然保持在67.6%。温度对强化硝化效果有显著影响,当水温从低于15 ℃缓慢升至25 ℃以上时,生物沸石人工湿地的氨氮平均硝化率从28%升至62%;强化硝化出水无明显的亚硝态氮积累现象,除低温阶段,出水亚硝态氮平均浓度为0.16 mg/L。氨氮主要是被微生物强化硝化成硝态氮。
- 强化硝化 /
- 二级出水 /
- 生物沸石 /
- 人工湿地 /
- 氨氮
Abstract: The bio-zeolite constructed wetland (CW) pilot plant receiving a real secondary effluent of the municipal wastewater treatment plant(WWTP) was set up. The performance of bio-zeolite CW enhancing the nitrification of the WWTP secondary effluent and the effect of temperature on nitrification rate were explored during 273 days. The results indicated that the N $H 4 +$ from secondary effluent was removed rapidly and effectively. Average removal rate of N $H 4 +$ was 90.5% and the concentration of N $H 4 +$ in the effluent was lower than 0.5 mg/L in the normal operation phase. After a short recovery period of 12 days, the average removal rate of N $H 4 +$ was higher than 70%. The average removal rate of N $H 4 +$ still remained at a relative high level as 67.6% in the low temperature stage (below 13 ℃). The temperature had signi?cant impact on the nitrification, and the average nitrification rate increased from 28% to 62% as the water temperature rose slowly from below 15 ℃ to above 25 ℃ in bio-zeolite CW. No obvious accumulation of nitrite nitrogen was found in the effluent of bio-zeolite CW except the low temperature stage, and the average concentration of nitrite nitrogen in the effluent was 0.16 mg/L. N $H 4 +$ was mainly nitrified by microorganisms and transformed into nitrate.
- enhanced nitration /
- secondary effluent /
- bio-zeolite /
- constructed wetland /
- N $H 4 +$

HTML全文

参考文献(37)

[1]	王正芳, 张继彪, 郑正 , 等. 物理强化复合人工湿地处理污水厂尾水实例[J]. 中国给水排水, 2013,29(2):75-77. WANG Z F, ZHANG J B, ZHENG Z , et al. Physically enhanced integrated constructed wetland for treating effluent from sewage treatment plant[J]. China Water and Wastewater, 2013,29(2):75-77.
[2]	段田莉, 成功, 郑媛媛 , 等. 高效垂直流人工湿地+多级生态塘深度处理污水厂尾水[J]. 环境工程学报, 2017,11(11):5828-5835. DUAN T L, CHENG G, ZHENG Y Y , et al. Advanced treatment of tail water from sewage plant by high-efficiency vertical flow constructed wetland-multistage ecological ponds[J]. Chinese Journal of Environmental Engineering, 2017,11(11):5828-5835
[3]	王玮 . 水平潜流人工湿地强化脱氮的技术及其机制研究[D]. 上海:东华大学, 2017. WANG W . Technique and mechanism of intensified nitrogen removal in horizontal subsurface flow constructed wetland[D]. Shanghai:Donghua University, 2017.
[4]	王亮 . 复合垂直流人工湿地对污水深度处理研究[D]. 合肥:合肥工业大学, 2016. WANG L . Advanced treatment of urban sewage by integreated vertical flow construded)wetland[D]. Hefei:Hefei University of Technology, 2016.
[5]	万正芬 . 城镇污水处理厂出水中氮磷高效吸附填料的筛选[D]. 青岛:中国海洋大学, 2015.
[6]	李冰 . 天然沸石填料曝气生物滤池脱氮性能[D]. 合肥:合肥工业大学; 2007. LI B . Study on the performance of denirifican in the zeolite biological aerated filter and bioregeneration of zeolite[D]. Hefei:Hefei University of Technology, 2007.
[7]	TAN E, HSU T C, HUANG X , et al.Nitrogen transformations and removal efficiency enhancement of a constructed wetland in subtropical Taiwan[J].Science of the Total Environment, 2017, 601/ 602:1378-1388. doi: 10.1016/j.scitotenv.2017.05.282
[8]	张曦, 吴为中, 温东辉 , 等. 生物沸石床污水脱氮效果及机理[J]. 环境科学, 2003,24(5):75-80. doi: 10.3321/j.issn:0250-3301.2003.05.014 ZHANG X, WU W Z, WEN D H , et al. Effect and mechanism of removal of nitrogen in the mimic sewage using bio-zeolite system[J]. Environmental Science, 2003,24(5):75-80. doi: 10.3321/j.issn:0250-3301.2003.05.014
[9]	ZHANG W, LEI Q, LI Z , et al. Temporal variation of nitrogen balance within constructed wetlands treating slightly polluted water using a stable nitrogen isotope experiment[J]. Environmental Science and Pollution Research Intermational, 2016,23(3), 2677-2683. doi: 10.1007/s11356-015-5485-4 pmid: 26438366
[10]	温东辉, 张曦, 吴为中 , 等. 天然沸石对铵吸附能力的生物再生试验研究[J]. 北京大学学报(自然科学版), 2003,39(4):494-500. doi: 10.3321/j.issn:0479-8023.2003.04.009 WEN D H, ZHANG X, WU W Z , et al. Research on bio-regeneration process of the ammonium adsorption capacity of natural zeolite[J]. Acta Scientiarum Naturalium Universitatis Pekinensis, 2003,39(4):494-500. doi: 10.3321/j.issn:0479-8023.2003.04.009
[11]	沈志强, 牟锐, 李元志 , 等. 人工湿地生物沸石快速吸附-再生性能与再生机理研究[J]. 环境科学学报, 2016,36(4):1242-1247. doi: 10.13671/j.hjkxxb.2015.0619 SHEN Z Q, MOU R, LI Y Z , et al. Study on the rapid adsorption-regeneration performance of bio-zeolite and its regeneration mechanism in aconstructed wetland[J]. Acta Scientiae Circumstantiae, 2016,36(4):1242-1247. doi: 10.13671/j.hjkxxb.2015.0619
[12]	张兵, 崔福义, 左金龙 , 等. 斜发沸石对氨氮的去除效果及其再生试验研究[J]. 中国给水排水, 2008,24(23):85-88. doi: 10.3321/j.issn:1000-4602.2008.23.021 ZHANG B, CUI F Y, ZUO J L , et al. Study on ammonia removal by clinoptilolite and its regeneration[J]. China Water and Wastewater, 2008,24(23):85-88. doi: 10.3321/j.issn:1000-4602.2008.23.021
[13]	卢少勇, 桂萌, 余刚 , 等. 人工湿地中沸石和土壤的氮吸附与再生试验研究[J]. 农业工程学报, 2006,22(11):64-68. doi: 10.3321/j.issn:1002-6819.2006.11.014 LU S Y, GUI M, YU G , et al. Nitrogen adsorption and reactivation of zeolite and soil in constructed wetland[J]. Transactions of the Chinese Society of Agricultural Engineering, 2006,22(11):64-68. doi: 10.3321/j.issn:1002-6819.2006.11.014
[14]	付国楷 . 活性污泥法-人工湿地联合处理城市污水研究[D]. 上海:同济大学, 2007. FU G K . Research on activated sludge progress-constructed wetland combinative technology treating municipal wastewate[D]. Shanghai:Tongji Unversity, 2007.
[15]	张磊 . 人工湿地系统对污水处理厂二级出水净化实验研究[D]. 西安:西安理工大学, 2010. ZHANG L . Study on treatment of efflunet in municipal secondary sewage plant with constructed wetland[D]. Xi’an:Xi’an University of Technology, 2010.
[16]	温东辉, 唐孝炎 . 天然斜发沸石对溶液中N$N_{4}^{+}$的物化作用机理[J]. 中国环境科学, 2003,23(5):509-514. doi: 10.3321/j.issn:1000-6923.2003.05.014 WEN D H, TANG X Y . Mechanism for physical-chemical actions of natural zeolite on N$N_{4}^{+}$ in solution[J]. China Environmental Science, 2003,23(5):509-514. doi: 10.3321/j.issn:1000-6923.2003.05.014
[17]	李德生, 黄晓东, 王占生 . 生物沸石反应器在微污染水源水处理中的应用[J]. 环境科学, 2000,21(5):71-73. doi: 10.3321/j.issn:0250-3301.2000.05.016 LI D S, HUANG X D, WANG Z S . Application of bio-zeolite reactor on micro-polluted source water quality treatment[J]. Environmental Science, 2000,21(5):71-73. doi: 10.3321/j.issn:0250-3301.2000.05.016
[18]	雒维国 . 潜流型人工湿地对氮污染物的去除效果研究[D]. 南京:东南大学, 2005. LUO W G . Study on removal efficiency of nitrogen pollutants in subsurface flow constructed wetland[D]. Nanjing:Southeast University, 2005.
[19]	AKRATOS C S, TSIHRINTZIS V A . Effect of temperature,HRT,vegetation and porous media on removal efficiency of pilot-scale horizontal subsurface flow constructed wetlands[J]. Ecological Engineering, 2007,29(2):173-191. doi: 10.1016/j.ecoleng.2006.06.013
[20]	MIETTO A, POLITEO M, BRESCHIGLIARO S , et al. Temperature influence on nitrogen removal in a hybrid constructed wetland system in Northern Italy[J]. Ecological Engineering, 2015,75:291-302. doi: 10.1016/j.ecoleng.2014.11.027
[21]	PENG L, HUA Y M, CAI J B , et al. Effects of plants and temperature on nitrogen removal and microbiology in a pilot-scale integrated vertical-flow wetland treating primary domestic wastewater[J]. Ecological Engineering, 2014,64:285-290. doi: 10.1016/j.ecoleng.2013.12.036
[22]	COOKSON W R, CORNFORTH I S, ROWARTH J S . Winter soil temperature(2-15 ℃) effects on nitrogen transformations in clover green manure amended or unamended soils:a laboratory and field study[J]. Soil Biology & Biochemistry, 2002,34:1401-1415.
[23]	ZHANG L Y, XIA X F, ZHAO Y , et al. The ammonium nitrogen oxidation process in horizontal subsurface flow constructed wetlands[J]. Ecological Engineering, 2011,37:1614-1619. doi: 10.1016/j.ecoleng.2011.06.020
[24]	张宇坤, 王淑莹, 董怡君 , 等. 游离氨和游离亚硝酸对亚硝态氮氧化菌活性的影响[J]. 中国环境科学, 2014,34(5):1242-1247. ZHANG Y K, WANG S Y, DONG Y J , et al. Effect of FA and FNA on activity of nitrite-oxidising bacteria[J]. China Environmental Science, 2014,34(5):1242-1247.
[25]	张曦, 吴为中, 温东辉 , 等. 氨氮在天然沸石上的吸附及解吸[J]. 环境化学, 2003,22(2):166-171. ZHANG X, WU W Z, WEN D H , et al. Adsorption and desorption of ammonia-nitrogen onto nautral zaolite[J]. Environmental Chemistry, 2003,22(2):166-171.
[26]	SAEED T, SUN G Z . Enhanced denitrification and organics removal in hybrid wetland columns:comparative experiments[J]. Bioresource Technology, 2011,102(2):967-974. doi: 10.1016/j.biortech.2010.09.056 pmid: 20934326
[27]	SAEED T, SUN G Z . A review on nitrogen and organics removal mechanisms in subsurface flow constructed wetlands:dependency on environmental parameters,operating conditions and supporting media[J]. Journal of Environmental Management, 2012,112:429-448. doi: 10.1016/j.jenvman.2012.08.011 pmid: 23032989
[28]	夏艳阳, 崔理华, 黄小龙 . 污水碳源对复合垂直流-水平流人工湿地脱氮效果的影响[J]. 环境工程学报, 2017,11(1):638-644. XIA Y Y, CUI L H, HUANG X L . Effect of internal carbon source supplement on nitrogen removal in integrated vertical-flow and horizontal-flow constructed wetland[J]. Chinese Journal of Environmental Engineering, 2017,11(1):638-644.
[29]	付国楷, 周琪, 杨殿海 , 等. 潜流人工湿地深度净化二级处理出水研究[J]. 中国给水排水, 2007,23(13):31-35. doi: 10.3321/j.issn:1000-4602.2007.13.008 FU G K, ZHOU Q, YANG D H , et al. Research on subsurface-flow constructed wetland for advanced treatment of secondary effluent[J]. China Water and Wastewater, 2007,23(13):31-35. doi: 10.3321/j.issn:1000-4602.2007.13.008
[30]	KOTTI I P, GIKAS G D, TSIHRINTZIS V A . Effect of operational and design parameters on removal efficiency of pilot-scale FWS constructed wetlands and comparison with HSF systems[J]. Ecological Engineering, 2010,36:862-875. doi: 10.1016/j.ecoleng.2010.03.002
[31]	WU H M, ZHANG J, NGO H H , et al. A review on the sustainability of constructed wetlands for wastewater treatment:design and operation[J]. Bioresource Technology, 2015,175:594-601. doi: 10.1016/j.biortech.2014.10.068 pmid: 25453440
[32]	杨林, 李咏梅 . 组合人工湿地处理工业园区污水厂尾水的中试研究[J]. 环境工程学报, 2012,6(6):1846-1850. YANG L, LI Y M . Pilot-scale study on advanced treatment of tail-water from wastewater treatment plant in industrial park using hybrid constructed wetland system[J]. Chinese Journal of Environmental Engineering, 2012,6(6):1846-1850.
[33]	BAI L L, WANG C H, HUANG C H , et al. Reuse of drinking water treatment residuals as a substrate in constructed wetlands for sewage tertiary treatment[J]. Ecological Engineering, 2014,70:295-303. doi: 10.1016/j.ecoleng.2014.06.015
[34]	GHOSH D, GOPAL B . Effect of hydraulic retention time on the treatment of secondary effluent in a subsurface flow constructed wetland[J]. Ecological Engineering, 2010,36:1044-1051. doi: 10.1016/j.ecoleng.2010.04.017
[35]	刘昌伟, 薛晨, 杨永哲 , 等. 新型潮汐流人工湿地深度处理生活污水的研究[J]. 中国给水排水, 2012,28(11):10-13. doi: 10.3969/j.issn.1000-4602.2012.11.003 LIU C W, XUE C, YANG Y Z , et al. Novel tidal-flow constructed wetland for advanced treatment of domestic sewage[J]. China Water and Wastewater, 2012,28(11):10-13. doi: 10.3969/j.issn.1000-4602.2012.11.003
[36]	韩梅, 高伟, 赵志伟 , 等. 悬浮填料-沸石BAF处理低温高氨氮污染源水效能[J]. 中国给水排水, 2015,31(1):32-40. HAN M, GAO W, ZHAO Z W , et al. Efficiency of biological aerated filter with suspended media and zeolite for treatment of low-temperature and high ammonia nitrogen source water[J]. China Water and Wastewater, 2015,31(1):32-40
[37]	丁绍兰, 封香香, 谢林花 . 沸石-核桃壳曝气生物滤池去除废水中氨氮的研究[J]. 工业水处理, 2017,37(5):45-49. DING S L, FENG X X, XIE L H . Research on the removal of ammonia nitrogen from wastewater by zeolite and walnut combined fillers of the biological aerated filter[J]. Industrial Water Treatment, 2017,37(5):45-49.